Maintenance method of golf car battery
1. If the battery is not used for a long time, it will discharge slowly until it is scrapped. Therefore, the ball car should be started every certain time to charge the battery.
2. When the ammeter pointer shows that the storage capacity is insufficient, it shall be charged in time. The storage capacity of the battery can be reflected on the instrument panel. Sometimes it is found that the power is not enough on the way, and the engine can’t be started again. As a temporary measure, you can ask other vehicles for help, start the vehicle with the battery on their vehicle, connect the negative pole and negative pole of the two batteries, and connect the positive pole and positive pole.
3. The density of electrolyte shall be adjusted according to standards in different regions and seasons.
4. In case of electrolyte loss, distilled water or special fluid shall be supplemented. Never use purified drinking water instead. Because pure water contains a variety of trace elements, it will have an adverse impact on the battery.
5. During daily driving, always check whether the small hole on the battery cover is ventilated. If the small hole of the battery cover is blocked, the generated hydrogen and oxygen cannot be discharged. When the electrolyte expands, the battery shell will be broken and the service life of the battery will be affected.
6. When charging, use a special charger and place it in a cool and ventilated place to avoid high temperature and humidity.
7. Do not use organic solvent to clean the battery shell.
8. Do not short circuit the positive and negative terminals of the battery to avoid danger.
9. No over discharge: when the red undervoltage display light on the instrument panel is on, it indicates that the power enters the hungry area and should be charged in time.
10. No overcharging: the charging time should vary according to the driving mileage. The longer the mileage, the longer the charging time, and vice versa.
11. In case of battery failure, please send it to the authorized Office of the manufacturer or relevant institutions for proper treatment. Please do not discard it at will to avoid environmental pollution.
Troubleshooting of golf car battery
Battery failure during gear shifting
When the golf cart needs to shift to gear 1 under special circumstances, the battery light of the golf cart will be on, but it will go out immediately, and the car is still normal. One of the reasons for this situation is that the engine is subject to great fluctuations and the battery is falsely connected, which may cause this situation in an instant. It is recommended to check the battery connection as soon as you get off the car.
Countermeasures for self discharge of golf cart battery
After the golf cart battery is placed for a period of time, its power consumption is called self discharge.
If the electrolyte on the battery cover is not clear and clean, the positive and negative poles of the monomer conduct electricity, resulting in self discharge.
The battery makes up for too many impurities in water, and the self discharge is faster.
The battery does not need to be placed for a long time, resulting in the sinking of sulfuric acid, the density of some electrolyte under the battery is higher than that above, and there is a potential difference between the upper and lower plates, resulting in self discharge.
Treatment method
When cleaning the outside of golf cart battery, pay attention to often remove the oxide and acid scale at the pole.
Deionized water or distilled water must be added when adding water to make up the battery.
If the filled battery needs to be stored for a long time, it should be replaced with a thinner electrolyte, and the battery should be recharged once a month.